PALMER INTERNATIONAL INC -- SUPERCLEAN  -- 6850-00N033340
<pre>=====================  Product Identification  =====================

Product ID:SUPERCLEAN
MSDS Date:02/04/1993
FSC:6850
NIIN:00N033340
=== Responsible Party ===
Company Name:PALMER INTERNATIONAL INC
Box:8
City:WORCESTER
State:PA
ZIP:19490
Country:US
Info Phone Num:215-584-4241
Emergency Phone Num:215-584-4241
CAGE:00933
=== Contractor Identification ===
Company Name:PALMER INTERNATIONAL,  INC.
Address:2955 SKIPPACK PIKE
Box:City:WORCESTER
State:PA
ZIP:19490
Country:US
Phone:610-584-4241
CAGE:00933

=============  Composition/Information on Ingredients  =============

Ingred Name:ING 15: WATER. NOTIFY PROPER AUTHORITIES AS REQUIRED BY
    LOCAL, STATE AND FEDERAL REGULATIONS.
RTECS #:9999999ZZ

Ingred Name:RESP PROT: SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ

Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE) (SARA
    313) (CERCLA)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: >95%
OSHA PEL:350 PPM
ACGIH TLV:350 PPM; 450 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Ingred Name:1,3-DIOXOLANE; (GLYCOL METHYLENE ETHER)
CAS:646-06-0
RTECS #:JH6760000
Fraction by Wt: <3%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:SEC-BUTYL ALCOHOL; (SEC BUTANOL) (SARA 313)
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: <2%
OSHA PEL:150 PPM
ACGIH TLV:100 PPM

Ingred Name:BUTANE, 1,2-EPOXY-; (1,2-BUTYLENE OXIDE) (SARA 313)
    (CERCLA)
CAS:106-88-7
RTECS #:EK3675000
Fraction by Wt: <0.5%
OSHA PEL:N/K 
ACGIH TLV:N/K 
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Ingred Name:VOLATILE ORGANIC COMPOUND: 1320 G/L
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:EFTS OF OVEREXP: CHRONIC TOX EFTS IN LAB ANIMALS MAY
    INDICATE TOX TO HUMANS. OVEREXP SHOULD BE AVOIDED; FAILURE (ING 7)
RTECS #:9999999ZZ

Ingred Name:ING 6: TO DO SO COULD RSLT IN INJURY, ILLNESS/EVEN DEATH.
    CHRONIC OVEREXPS TO 1,1,1 TRICHLOROETHANE HAVE CAUSED (ING 8)
RTECS #:9999999ZZ

Ingred Name:ING 7: LIVER TOX EFTS IN EXPERIMENTAL ANIMALS. BUTYLENE
    OXIDE HAS BEEN EVALUATED FOR POSS CANCER CAUSING EFTS IN (ING 9)
RTECS #:9999999ZZ

Ingred Name:ING 8: LAB ANIMALS. IN ONE STUDY, RATS WERE EXPOS TO LEVELS
    UP TO 400PPM, 6 HRS/DAY, 5 DAYS/WK FOR 2 YRS. THERE (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9: WAS INCR IN NASAL & LUNG TUMORS IN MALE RATS. IN
    ANOTHER STUDY, MICE EXPOS UP TO 100PPM, 6 HRS/DAY, (ING 11)
RTECS #:9999999ZZ

Ingred Name:ING 10: 5 DAYS/WK FOR 2 YRS, NO INCREASED INCIDENCE OF
    CANCER OBSERVED. TWO OF THREE STUDIES INVOLVING (ING 12)
RTECS #:9999999ZZ

Ingred Name:ING 11: 1,1,1 TRICHLOROETHANE INDICATE NO REPRO TOX. THIRD
    STUDY NOTED DELAYS IN NORM DEVELOPMENT, BUT DID NOT (ING 13)
RTECS #:9999999ZZ

Ingred Name:ING 12: AFFECT LATER LIFE. TWO STUDIES INVOLVING BUTYLENE
    OXIDE FOUND NO TERATOGENIC EFTS IN EXPOSED RATS/RABBITS.
RTECS #:9999999ZZ

Ingred Name:FIRST AID PROC: RESPIRATION. KEEP PERSON WARM, QUIET & GET
    MEDICAL ATTENTION.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC: SAND, FLOOR ABSORB OR OTHER ABSORB MATL &
    SHOVELED INTO CNTNRS. PVNT RUN-OFF TO SEWERS & BODIES OF (ING 16)
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50: (ORAL, RATS) > 10,000 MG/KG
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRDCED SENSIT
    OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR
    EFT IN HUMANS. ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
    CONTRA-INDICATED EXCEPT FOR LIFE-SUSTAININ G USES IN HUMANS
    ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS . EYES:CAN CAUSE SEV
    IRRIT, REDNESS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TEARING, BLURRED VISION.
    SKIN:PRLNG/RPTD CNTCT CAN CAUSE MOD IRRIT, DEFAT, DERM.
    INHAL:EXCESS INHAL OF VAPS &/OR SPRAY MIST CAN CAUSE RESP IRRIT,
    DIZZ, WEAK, FATG, NAUS, HDCH, UNCON. INGEST:S INGLE DOSE ORAL TOX
    IS LOW. CAN BE ABSORBED THRU LUNGS & CAUSE CHEM PNEUM WHICH CAN BE
    FATAL. CHRONIC: FINDING (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:EYES:FLUSH W/LG AMTS OF WATER LIFTING LIDS OCCAS; GET PROMPT
    MED ATTN. SKIN: WASH THORO W/SOAP & WATER, REMOVE CONTAMD CLTHG
    PROMPTLY; WASH CLTHG BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT!
    KEEP WARM,	QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS DUE TO
    VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL: MOVE TO FRESH
    AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, GIVE
    ARTF (ING 14)

=====================  Fire Fighting Measures  =====================

Flash Point:NONE
Lower Limits:7.5%
Upper Limits:15.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
    WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
    AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMP PROD MAY INCL HCL &
    PHOSGENE . VAPS ARE HVR/AIR & MAY TRAVEL ALONG GROUND TO IGNIT
    SOURCE SOME DIST FROM MATL HNDLG POINT. IGNIT (SUPDAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:SM SPILL:ABSORB LIQ W/RAGS, FLOOR ABSORB,
    VERMICULITE/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM ALL
    IGNIT SOURCES. DIKE AREA OF SPILL TO PVNT SPREAD. VENT AREA IF
    INDOORS. PUMP LIQ INTO SALV AGE TANK. REMAINING LIQ MAY TAKEN UP
    WITH (ING 15)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS
    AWAY FROM SOURCES OF IGNITION.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
    VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
    UV RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF TLV OF PROD IS EXCEEDED, NIOSH/MSHA APPRVD
    AIR SUPPLY RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CTL. OSHA
    REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER SPECIFIED
    CNDTNS (SEE SFTY EQUIP SU PPLIER). ENGINEERING/ADMIN CTLS (ING 17)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
    EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:RESISTANT GLOVES SUCH AS NITRILE RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH; SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP: 100 @ 20C FOR THE BLEND. EXPLO HAZ: SOURCES INCL PILOT LIGHTS,
    SMKNG, HEATERS, ELEC MOTORS, SPKS FROM ELEC SWITCHES & STATIC
    DISCHARGES. CAUTION: NEVER USE CUTTING TORCH ON EMPTY CNTNRS!
    RESIDUAL  SOLV VAP IN EMPTY CNTNR MAY EXPLODE.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>160F,>71C
Vapor Pres:SUPDAT
Vapor Density:HVR/AIR
Spec Gravity:1.32
Evaporation Rate &amp; Reference:FASTER/N-BUTYL ACETATE
Appearance and Odor:CLEAR LIQUID.
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH WATER ON A LONG TERM BASIS. STRONG ALKALIES,
    OXIDIZERS, ALUMINUM & OTHER REACTIVE METALS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME. AVOID
    LONG TERM STORAGE IN ALUMINUM.
Hazardous Decomposition Products:MAY FORM HYDROGEN CHLORIDE AND SMALL
    AMOUNTS OF CHLORINE AND PHOSGENE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:SMALL SPILL: ALLOW VOLATILE PORTION TO EVAPORATE
    IN HOOD. DISPOSE OF REMAINING MATERIAL I/A/W APPLIC FEDERAL, STATE
    & LOCAL REGULATIONSS. LARGE SPILL: MUST BE DISPOSED OF BY AN
    APPROVED DISPOSAL CONTR ACTOR I/A/W LOCAL, STATE & FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.